金凌峰,刘灏,郑一鸣,杨智,梁苏宁,张凡
JIN Lingfeng,LIU Hao,ZHENG Yiming,YANG Zhi,LIANG Suning,ZHANG Fan

• 1:国网浙江省电力有限公司电力科学研究院
• 2:电力设备电气绝缘国家重点实验室(西安交通大学)

摘要(Abstract)：

当重合闸重合于永久性故障时，会给变压器带来二次冲击，增加变压器损坏的可能性。对此，首先建立了三绕组变压器“高-中-低”运行方式下的漏磁场计算模型；之后建立了绕组线圈轴向振动的非线性模型，并提出线饼及垫块上所受轴向压力的动态计算方法；最后利用所建立模型对一台110 kV变压器在重合闸工况下的轴向强度进行评估。结果表明，重合于最劣工况时，变压器漏磁场增加，振动更为剧烈，作用于线圈及垫块上的力更大，变压器出现轴向不稳定的可能性增大。研究结果可为变压器重合闸工况校核提供依据。
Reclosing during a permanent fault subjects the transformer to secondary impacts, thereby increasing the likelihood of transformer damage. In this paper, a computational model for calculating the leakage magnetic field of a three-winding transformer operating in "high-medium-low" mode is first established. Subsequently, a nonlinear model for the axial vibration of winding coils is developed, and a dynamic calculation method for the axial pressure on the coils and spacers is proposed. Finally, the established model is utilized to evaluate the axial strength of a 110 kV transformer under reclosing operation conditions. The results indicate that during reclosing in the poorest operating condition, the leakage magnetic field of the transformer increases, vibrations become more intense, and the forces acting on the coils and spacers are greater, thereby increasing the possibility of axial instability in the transformer.These findings can provide a basis for the verification of operating conditions for transformers during reclosing.

关键词(KeyWords)： 重合闸;变压器绕组;动稳定性
reclosing;transformer winding;dynamic stability

Abstract:

Keywords:

基金项目(Foundation): 国家电网有限公司总部科技项目（5500-202219126A-1-1-ZN）

作者(Author): 金凌峰,刘灏,郑一鸣,杨智,梁苏宁,张凡
JIN Lingfeng,LIU Hao,ZHENG Yiming,YANG Zhi,LIANG Suning,ZHANG Fan

DOI: 10.19585/j.zjdl.202406012

参考文献(References)：

• [1] Working Group A2.37.Transformer reliability survey[R].Paris:CIGRE,2015.
• [2]凌愍，古正香.1990—1994年全国变压器事故统计及分析[J].电网技术，1996,(9):47-52.LING Min,GU Zhengxiang. Nation-wide fault statistics and analysis of transformers from 1990 to 1994[J].Power System Technology,1996,(9):47-52.
• [3]王梦云.110 kV及以上变压器事故统计分析[J].供用电，2006,23(1):1-4.
• [4]刘泽洪，卢理成，周远翔，等.变压器升高座区域电弧故障与压力特性研究[J].中国电机工程学报，2021,41(13):4688-4698.LIU Zehong,LU Licheng,ZHOU Yuanxiang,et al. Research on pressure characteristics of AC turret on arc fault[J].Proceedings of the CSEE,2021,41(13):4688-4698.
• [5]汲胜昌，张凡，师愉航，等.基于振动信号的电力变压器机械状态诊断方法研究综述[J].高电压技术，2020,46(1):257-272.JI Shengchang,ZHANG Fan,SHI Yuhang,et al.Review on vibration-based mechanical condition monitoring in power transformers[J].High Voltage Engineering,2020,46(1):257-272.
• [6]熊汉武，张书琦，赵志刚，等.电力变压器绕组幅向弯曲应力分析方法[J].高电压技术，2020,46(3):931-938.XIONG Hanwu,ZHANG Shuqi,ZHAO Zhigang,et al.Analysis method of radial bending stress of power transformer windings[J]. High Voltage Engineering,2020,46(3):931-938.
• [7] BAKSHI A. An investigation of winding curvature effect on the mechanical strength of transformer windings[J].IEEE Transactions on Power Delivery,2015,30(4):1821-1826.
• [8] GEISSLER D,GEISSLER C,LEIBFRIED T.Simplified simulation model of continuously transposed cable for linear and nonlinear buckling analysis[J]. Mathematics and Computers in Simulation,2016,130:81-94.
• [9] PATEL M R. Instability of the continuously transposed cable under axial short-circuit forces in transformers[J].IEEE Transactions on Power Delivery,2002,17(1):149-154.
• [10] BAKSHI A,KULKARNI S V.Eigenvalue analysis for investigation of tilting of transformer winding conductors under axial short-circuit forces[J]. IEEE Transactions on Power Delivery,2011,26(4):2505-2512.
• [11] BAKSHI A,KULKARNI S V. Analysis of buckling strength of inner windings in transformers under radial short-circuit forces[J].IEEE Transactions on Power Delivery,2014,29(1):241-245.
• [12]赵志刚，李光范，李金忠，等.基于有限元法的大型电力变压器抗短路能力分析[J].高电压技术，2014,40(10):3214-3220.ZHAO Zhigang,LI Guangfan,LI Jinzhong,et al.Analyzing the short-circuit withstanding ability of large power transformer based the FEM method[J].High Voltage Engineering,2014,40(10):3214-3220.
• [13]陈振茂，徐健学.大型电力变压器线圈轴向非线性振动研究[J].应用力学学报，1990,7(1):21-29.CHEN Zhenmao,XU Jianxue.The nonlinear vibration of large transformer windings[J].Chinese Journal of Applied Mechanics,1990,7(1):21-29.
• [14]张凡，马程，李秀广，等.计及振动响应的变压器绕组轴向机械强度动态评估方法研究[J].中国电机工程学报，2023,43(16):6494-6505.ZHANG Fan,MA Cheng,LI Xiuguang,et al.Dynamic assessment of windings’ axial mechanical strength in power transformers considering the vibration response[J]Proceedings of the CSEE,2023,43(16):6494-6505.
• [15]冉德东，孟天男，王雄博，等.三绕组电力变压器单相接地短路电流及绕组强度计算[J].变压器，2022,59(4):48-53.RAN Dedong,MENG Tiannan,WANG Xiongbo,et al.Calculation of single-phase grounding short-circuit current and winding strength of three-winding power transformer[J].Transformer,2022,59(4):48-53.
• [16]罗兵，王婷婷，贾磊，等.基于镜像磁场和动力学模型的变压器负载振动噪声数字孪生模型研究[J].高压电器，2022,58(7):141-148.LUO Bing,WANG Tingting,JIA Lei,et al.Investigation of digital twin model of transformer load vibro-acoustic characteristics based on the image method and dynamic model[J].High Voltage Apparatus,2022,58(7):141-148.