一起变电站35kV母线电压互感器高压熔丝异常熔断故障分析Analysis on High-voltage Fuse Melting of 35 kV Bus Potential Transformer in a Substation
胡冬良,艾飞,章立新
HU Dongliang,AI Fei,ZHANG Lixing
摘要(Abstract)：
针对某220 k V变电站35 k V母线电压互感器高压熔丝频繁熔断现象,结合变电站的系统运行方式,通过对统计数据进行分析,逐步排除了二次消谐装置异常、熔丝过热等一系列因素;通过在35k VⅡ段母线加装电压电流监视装置,对电压电流信号进行录波分析,发现由于电压互感器抗饱和特性裕度不足,额定电流0.5 A熔丝抗电流扰动性能较差,导致熔丝频繁承受脉动过电压和脉动冲击电流,进而引起熔丝逐步受损熔断。最后结合研究结果提出合理的建议及改造方案,并通过试验验证了改造方案的可行性。
In order to investigate the reasons of frequent high-voltage fuse melting of 35 k V bus potential transformer in a substation,a number of factors such as the second harmonic elimination device abnormality and fuse overheat are excluded through substation operation mode and statistic data analysis.Voltage and current monitoring device is installed on 35 k V sectionⅡ bus to record the wave and analysis the voltage and current signals.The paper indicates that due to insufficient anti-saturation characteristic margin of PT and poor current anti-interference capability of rated current 0.5 A fuse,impact on PT fuse from impulse overvoltage and current frequently occurs,which eventually causes fuse damage and blow.In the end,reasonable proposals and rehabilitation programs are put forward,and the feasibility of rehabilitation programs is verified by tests.
关键词(KeyWords)：
电压互感器;脉动过电压;脉动冲击电流;高压熔丝;熔断
potential voltage;impulse overvoltage;current frequently occurs;high voltage fuse;melting
基金项目(Foundation):
作者(Author):
胡冬良,艾飞,章立新
HU Dongliang,AI Fei,ZHANG Lixing
DOI: 10.19585/j.zjdl.2017.01.002
参考文献(References)：
- [1]张由桂.电磁式电压互感器高压熔丝熔断的原因及处理方法[J].电气应用,2007(4):28-29.
- [2]王明钦,陈维江,李永君,等.油田35 k V系统电压互感器高压熔丝异常熔断故障的抑制措施[J].电网技术,2012,36(12):283-288.
- [3]胡冬良,章立新,艾飞.35 k V母线电压互感器高压熔丝频繁熔断原因分析及探讨[C].//中国高等学校电力系统及其自动化专业第29届学术年会,2013.
- [4]葛栋.配电网电磁式电压互感器饱和引起的过电压及过电流的计算分析与抑制措施研究[D].武汉:武汉大学,2004.
- [5]武万才,吴志勇,边疆,等.地区电网电磁式电压互感器烧损和高压熔丝熔断原因分析[J].高压电器,2011,47(3):87-92.
- [6]GB/T 15166.2-1994交流高压熔断器限流式熔断器[S].北京:国家技术监督局,1994.
- [7]GB/T 15166.2-2008高压交流熔断器第2部分:限流熔断器[S].北京:中国标准出版社,2008.
- [8]马利东,杜忠.电压互感器高压熔丝频繁熔断故障原因探讨[J].农村电气化,2014(9):29-30.
- [9]乔永亮.变电站35 k V母线压变熔丝频繁熔断分析[J].华中电力,2014(2):32-34.
- [10]蔡源,傅剑文,饶源.10 k V TV高压熔丝熔断原因分析及防止措施[J].浙江电力,2010,29(4):23-26.
- [11]吴尊,朱旭,王晓明.电磁式电压互感器空载励磁电流异常原因分析[J].浙江电力,2010,29(1):18-22.